Coffs Harbour

The aircraft impacted the sea or a reef about 6 km north-east of Coffs Harbour airport. The impact occurred immediately after the pilot initiated a go-around during an instrument approach to runway 21 in Instrument Meteorological Conditions (IMC) that included heavy rain and restricted visibility. Although the aircraft sustained structural damage and the left main gear detached, the aircraft remained airborne. During the initial go-around climb, the aircraft narrowly missed a breakwater and adjacent restaurant at the Coffs Harbour boat harbour. Shortly after, the pilot noticed that the primary attitude indicator had failed, requiring him to refer to the standby instrument to recover from an inadvertent turn. The pilot positioned the aircraft over the sea and held for about 30 minutes before returning to Coffs Harbour and landing the damaged aircraft on runway 21. There were no injuries or any other damage to property and/or the environment because of the accident. The aircraft was on a routine aeromedical flight from Sydney to Coffs Harbour with the pilot, two flight nurses, and a stretcher patient on board. The flight was conducted under instrument flight rules (IFR) in predominantly instrument meteorological conditions (IMC). During the descent, the enroute air traffic controller advised the pilot to expect the runway 21 Global Positioning System (GPS) non-precision approach (NPA). The pilot reported that he reviewed the approach diagram and planned a 3-degree descent profile. He noted the appropriate altitudes, including the correct minimum descent altitude (MDA) of 580 ft, on a reference card. A copy of the approach diagram used by the pilot is at Appendix A. The aerodrome controller advised the pilot of the possibility of a holding pattern due to a preceding IFR aircraft being sequenced for an instrument approach to runway 21. The controller subsequently advised that holding would not be required if the initial approach fix (SCHNC)2 was reached not before 0825. At about 0818, the aerodrome controller advised the pilot of the preceding aircraft that the weather conditions in the area of the final approach were a visibility of 5000 m and an approximate cloud base of 1,000 ft. At 0825 the aerodrome controller cleared the pilot of the King Air to track the aircraft from the initial approach fix to the intermediate fix (SCHNI) and to descend to not below 3,500 ft. The published minimum crossing altitude was 3,600 ft. About one minute later the pilot reported that he was leaving 5,500 ft and was established inbound on the approach. At 0828 the pilot reported approaching the intermediate fix and 3,500 ft. The controller advised that further descent was not available until the preceding aircraft was visible from the tower. At 0829 the controller, having sighted the preceding aircraft, cleared the pilot of the King Air to continue descent to 2,500 ft. The pilot advised the controller that he was 2.2 NM from the final approach fix (SCHNF). At that point an aircraft on a 3-degree approach slope to the threshold would be at about 2,500 ft. The controller then cleared the pilot for the runway 21 GPS approach, effectively a clearance to descend as required. The pilot subsequently explained that he was high on his planned 3-degree descent profile because separation with the preceding aircraft resulted in a late descent clearance. He had hand flown the approach, and although he recalled setting the altitude alerter to the 3,500 ft and 2,500 ft clearance limits, he could not recall setting the 580 ft MDA. He stated that he had not intended to descend below the MDA until he was visual, and that he had started to scan outside the cockpit at about 800 ft altitude in expectation of becoming visual. The pilot recalled levelling the aircraft, but a short time later experienced a 'sinking feeling'. That prompted him to go-around by advancing the propeller and engine power levers, and establishing the aircraft in a nose-up attitude. The passenger in the right front seat reported experiencing a similar 'falling sensation' and observed the pilot's altimeter moving rapidly 'down through 200 ft' before it stopped at about 50 ft. She saw what looked like a beach and exclaimed 'land' about the same time as the pilot applied power. The pilot felt a 'thump' just after he had initiated the go-around. The passenger recalled feeling a 'jolt' as the aircraft began to climb. Witnesses on the northern breakwater of the Coffs Harbour boat harbour observed an aircraft appear out of the heavy rain and mist from the north-east. They reported that it seemed to strike the breakwater wall and then passed over an adjacent restaurant at a very low altitude before it was lost from sight. Wheels from the left landing gear were seen to ricochet into the air and one of the two wheels was seen to fall into the water. The other wheel was found lodged among the rocks of the breakwater.During the go-around the pilot unsuccessfully attempted to raise the landing gear, so he reselected the landing gear selector to the 'down' position. He was unable to retract the wing flaps. It was then that he experienced a strong g-force and realised that he was in a turn. He saw that the primary attitude indicator had 'toppled' and referred to the standby attitude indicator, which showed that the aircraft was in a 70-degree right bank. He rapidly regained control of the aircraft and turned it onto an easterly heading, away from land. The inverter fail light illuminated but the pilot did not recall any associated master warning annunciator. He then selected the number-2 inverter to restore power to the primary attitude indicator, and it commenced to operate normally. The pilot observed that the left main landing gear had separated from the aircraft. He continued to manoeuvre over water while awaiting an improvement in weather conditions that would permit a visual approach. About 4 minutes after the King Air commenced the go-around, the aerodrome controller received a telephone call advising that a person at the Coffs Harbour boat harbour had witnessed an aircraft flying low over the harbour, and that the aircraft had '…hit something and the wheel came off'. The controller contacted the pilot, who confirmed that the aircraft was damaged. The controller declared a distress phase and activated the emergency response services to position for the aircraft's landing. Witnesses reported that the landing was smooth. As the aircraft came to rest on the runway, foam was applied around the aircraft to minimise the likelihood of fire. The occupants exited the aircraft through the main cabin door.

The aircraft was operating a scheduled service from Brisbane to Port Macquarie with planned intermediate stops at Coolangatta and Coffs Harbour. Weather conditions over the route were influenced by a widespread unstable airmass. The terminal forecast for Coffs Harbour indicated a surface wind of 360/15, visibility in excess of 10 km, 5 octas stratus at 1000 ft, 5 octas cumulus at 2000 ft. Thunderstorms, associated with visibility reduced to 2000 metres were also forecast for periods of up to 30 minutes. The actual weather conditions at Coffs Harbour were generally consistent with the terminal forecast. Runway 03 was in use throughout the evening. Coffs Harbour airport was equipped with NDB, VOR and domestic DME radio navigation aids. A VOR/DME procedure was published for runway 03 approaches. For aircraft not equipped with DME, a VOR or NDB approach was available using common tracking and minimum altitude criteria. Runway 03 was also equipped with a 6 stage T-VASIS and 3 stage runway lighting. All facilities were reported as functioning normally, with the exception of the VOR which was experiencing intermittent power failures due to the effects of heavy rain. The VOR was able to be reset manually from the Coffs Harbour control tower. Although the tower was scheduled to be unmanned before the arrival of VH-HOX, the duty air traffic controller elected to man the tower until the aircraft had landed. The controller also called out a technician to attend to the VOR. The aircraft was equipped with dual ILS/VOR and ADF receivers, plus International DME. Domestic DME equipment was not fitted to the aircraft, although required by ANO 20.8. After descending in the VOR/NDB holding pattern, the aircraft was cleared for an instrument approach. The pilot had been told of the intermittent operation of the VOR and had said he would revert to the NDB. At that time the weather conditions were fluctuating about the circling minima of 950 feet (QNH) and five km visibility. The controller advised the aircraft of a heavy shower to the south of the field. The aircraft subsequently completed the approach and the pilot reported "visual". The controller said he saw the lights of the aircraft in a position consistent with a right downwind leg for a landing on runway 03. The aircraft was then cleared to land. Shortly after, the controller saw the lights of the aircraft disappear briefly, consistent with the aircraft passing through a localised area of rain/cloud. The lights then reappeared briefly, as though the aircraft was turning onto finals, before disappearing. This was immediately followed by short series of "clicks" on the tower frequency. The aircraft was called immediately but failed to respond to any calls. The accident site was located about 1070 metres short of the landing threshold, and about 750 metres to the right of the extended runway centreline. The aircraft was found to have initially struck a nine metre high tree in a nose low attitude, steeply banked to the right, on a track of 050 degrees. After striking the tree with the outboard section of the right wing, the aircraft struck other trees before hitting the ground and overturning. A fire broke out shortly after the aircraft came to rest. As a result of his remaining on duty, the controller was able to provide immediate notification of the accident to the emergency services. This action facilitated the rescue of survivors.

The pilot reported that shortly after the aircraft became airborne, he noted a substantial change in propeller pitch noise and an associated loss of performance. Insufficient runway remained to permit a landing straight ahead. The pilot raised the landing gear and flap, however the aircraft failed to climb and the airspeed decayed to below the safe single engine speed. The take-off attempt was abandoned and a forced landing was carried out off the end of the runway. The rear fuselage impacted heavily on a dirt bank 78 metres beyond the runway threshold, following which the aircraft passed through a fence and slid for a further 78 metres before coming to rest. All nine occupants escaped uninjured.

While completing a training sortie, the pilot became lost. Due to fuel exhaustion, he was forced to attempt an emergency landing on a beach located in Coffs Harbour. While all four crew members were rescued, the aircraft was lost. The accident occurred after a flight of almost 6 ½ hours, two hours beyond the accepted endurance.
Crew:
F/O James M. Swann, pilot,
A. H. Morton, wireless operator and air gunner 2.